Please note that JavaScript and style sheet are used in this website,
Due to unadaptability of the style sheet with the browser used in your computer, pages may not look as original.
Even in such a case, however, the contents can be used safely.

Environmental Data: Environmental Management

Number of Certified Environmental Auditors (CEAR Registration)

Registered CEARs (Note 1) that can perform ISO assessments are trained to facilitate improvements in the quality of environmental management assessment.

As of March 2013

  FY2011 FY2012 FY2013
Lead Auditors (Note 2) 21 21 20
Auditors (Note 2) 38 38 33
Provisional Auditors (Note 2) 46 40 40
Total 105 99 93

(Note 1) CEAR: The Center of the Environmental Auditors Registration
(Note 2) No. of potential participants in NEC Group assessment

Handling of Accidents and Complaints

Since FY 1999, we have announced whether any fines or penalties concerning environmental matters have been levied on NEC.
No such fines or penalties were levied in FY 2012. This is not to say the year was entirely accident free. We had no accident that would affect the areas beyond our site perimeters, and had 4 accidents that were contained within our site and no complaint. We initiated clean-up operations immediately after the accidents and devised measures to prevent future occurrences. These measures were implemented at all sites.

Accidents

Accidents with Impact Outside the Company  
  FY2012 FY2013
Accident Details
  1. An organic solvent from recovery equipment flowed into rainwater gutters outside company premises.
  2. Drain water exceeding the tolerable level of soluble iron flowed out due to a problem with a pretreatment facility.
 No accidents with impact outside the company
Action Taken
  1. Establishment of dual safety system that prevents leakage even if the error occurs
  2. Review of daily checkup, such as pipes
  3. Enhancement of the education about measures against leakage
  4. Familiarizing employees with the required procedures
Accidents with No Impact Outside the Company  
  FY2012 FY2013
Accident Details
  1. Leak of chemical (organic solvent) (5 accidents)
  2. The voluntary control value for drain water was exceeded. (3 accidents)
  1. Level exceeded voluntary control value in waste water treatment facility (1 accident)
  2. Leakage of dust from disposal duct of dust collector (1 accident)
  3. Leakage of chemicals (oil, gas) from facilities (2 accidents)
  4. Ignition by a chemical reaction in a laboratory
Action Taken
  1. Establishment of dual safety system that prevents leakage even if the error occurs
  2. Review of daily checkup, such as pipes
  3. Enhancement of the education about measures against leakage
  4. Familiarizing employees with the required procedures
  1. Establishment of dual safety system that prevents leakage even if the error occurs
  2. Review of daily checkup, such as pipes
  3. Enhancement of the education about measures against leakage
  4. Familiarizing employees with the required procedures

Complaints

Complaints  
  FY2012 FY2013
Complaints Noise (2 incident) None
Action Taken
  1. Investigation of the causes, emergency measures
  2. Offering an apology, explanation on situation, information disclosure

Emergency Response Training

  Number of Times Performed Number of Trainees Hours Spent in Training
FY2013 251 1,088 496
FY2012 59 482 57
FY2011 63 556 67